Zigmont Magic FX Inc. - Effects Specialist® - Special Effects Designer - We provide the entire spectrum of Special Effects for Events Since 1990

Effect Specialist™ Special Effects Designer for Flames for at Special Events

Special Effect Expert for Propane Flames Firefly Cannons and Gas Flame Effects

We did  Big 30 foot propane Flames At the Everest Challenge at Disney's Animal Kingdom May 3rd 2014  for theDisney Run Expedition Everest Challenge 5K # nigh ttime.  We provided Snow Effects 2013 event.

While Disney could hire anyone, Disney special effects dept  pick Zigmont Magic FX as the best Vendor to do this safe as the the  event was open to the general Public.

Propane Flames in a light rain mist at Disney

Looking for Special Effects Propane or Gas Effects in Florida, like you seen on Stage or in a Movie?

While you can find Flame Systems From China for Very Cheap either from china direct or from a USA on line dealer, these systems do not comply or conform to NFPA 160.2006 code. The fire marshals will not allow with out these units being made to complaint to USA Code. These can not be used in the USA because they are not Labeled and Listed. These systems have very little safety protocol and do not follow USA code. These systems are made to Chinese code. These systems have not been indpendently tested

NFPA 160

Flame Effect Classification - NFPA 160 Group 3

1. Clearance of Flame from performer and to a proximity audience; Clearance -10 feet from any performer and 20 feet + from audience.
An audience should be located so that the incident thermal radiation received does not exceed that calculated by the following equation:
When applying the preceding equation to an effect with a duration of 4 seconds or less, the time used in calculating the maximum acceptable level of incident thermal flux should correspond to the root mean square (RMS) value of the peak incident thermal flux.
The incident radiation should not cause the surface temperature of the exposed skin of a member of the audience to exceed 111°F (44°C). Incident radiation can be measured with a radiometer. Skin temperature can be measured with an infrared surface thermometer or other equivalent means.


2. Propane fuels - use approved hoses and E - Valves. A labeled and listed, fast-closing valve that automatically and completely shuts off the fuel supply in response to a normal or safety shutdown. Every controller provides feedback as to the status of the flame unit (flame sensing,shutoff on ignition failure). Redundant PLC's (programmable logic controller) and double shut off values to the either 5-11-20-40 pound feeder tanks.
   


3. Propane Cylinders size 5 - 11 - 20 -pound bottles will be 10 feet away from flame source or the flame head separated by a metal layer with flame on top and tank under the flame within the structure (see photo below). Cylinders stored in buildings in accordance with Section NFPA 58 8.3 shall not be located near exits, stairways, or in areas normally used, or intended to be use, for the safe egress of people. We will not interfere with the safe and efficient means of leaving the building or facility under emergency circumstances. We will be 10 feet from any exits, stairways and doors.



New: NFPA 58 8.3.1(a) 2008 If more than one such cylinder is located in the same room, the cylinders shall be separated by at least 20 ft (6.1 m). 20 feet from doorways, Cylinder not located near exit, stairways or near safe egress of occupants.

(a) The flame effect shall comply with NFPA 160, Standard for Flame Effects Before an Audience.

(b) The maximum water capacity of individual cylinders shall be 50 lb (23 kg) {nominal 20 lb. (9.1 kg) LP-Gas capacity}.

(c) If more than one such cylinder is located in the same room, the cylinders shall be separated by at least 20 ft (6.1 m).

4. Heads have a pilot confirmation and a safety control with two shut off values. Flames units shall be design to prevent accidental firing and emergency (E-Stop) stop Safety Shutoff Valve .All hose connections will have a shut off. A listed, fast-closing valve that automatically and completely shuts off the fuel supply in response to a normal or safety shutdown. Which is a mandatory requirement.
   


5. Propane Flame heads should have a safety system like a Honeywell intermittent pilot module, providing system status and feedback with its sensors. Primary Safety Control. A control with a sensor that is directly responsive to the ignition device attributes necessary for the safe operation of the effect. In the event of ignition failure or loss of flame, the control causes a safety shutdown.
   "During the arming sequence, the Honeywell creates a high voltage spark on the pilot assembly. The pilot valve is energized and a solid pilot flame should be established. The rectification sensor will be detect the pilot flame and report back to the Honeywell that a solid pilot has been established. Upon detection of a solid pilot flame, the main flame firing circuit is armed. Only then can flame fuel be issued."
   


6. The incident radiation should not cause the surface temperature of the exposed skin of a member of the audience to exceed 44°C (111°F). Incident radiation can be measured with a radiometer with a 4 second flame burst or less. Skin temperature can be measured with an infrared surface thermometer or other equivalent means. Incident thermal fluxes and resulting surface temperatures on the glazing surfaces is one tool to determine the table of distance.
   


7. Temperatures of combustible materials subject to the heat of the flame effect shall not exceed 117°F (47.2°C) above the ambient temperature after equilibrium temperatures are attained. The temperatures shall be observed until a maximum or stable reading has been attained. The incident radiation is another tool to determine the table of distance.
   


8. Location and Accessibility of Control Systems. Control system components and protective devices, including sensors, valves, and switches, shall be located so that they are protected against physical damage and tampering. Control system components shall be located so that they can be serviced and maintained.
   


9. System should be approved and certified by ARL ( Applied Research Laboratory), NRTL, UL, North American TUV Mark Standards, State Mechanic Certified to comply with NFPA 160.2001 Codes.
   Listed.* Equipment, materials, or services included in a list published by an organization that is acceptable to the authority having jurisdiction and concerned with evaluation of products or services, that maintains periodic inspection of production of listed equipment or materials or periodic evaluation of services, and whose listing states that either the equipment, material, or service meets identified standards or has been tested and found suitable for a specified purpose.
   Labeled * Equipment or materials to which has been attached a label, symbol, or other identifying mark of an organization that is acceptable to the authority having jurisdiction and concerned with product evaluation, that maintains periodic inspection of production of labeled equipment or materials, and by whose labeling the manufacturer indicates compliance with appropriate standards or performance in a specified manner.
   


10. Rehearse the Flame Effect before the show" "This will let you know, in a safe environment, how the product will perform in the venue, and if there are any additional changes that need to be made to account for the flame effects." If you are using talent, be sure to include them in the Propane Flame rehearsal. "This will allow the artist to be familiar with the effect and to maintain a comfortable distance from the devices while performing.

How The Olympic Torino Torch Works
The 2006 Olympic Relay torch is 30.31 inches (770 mm) long. It has an aluminum alloy shell, and its burner and fuel pipe are made from a brass and copper alloy. The Toronto torch burns 40% polypropylene/60% butane fuel from a pressurized canister. The torches included a burner system that utilized a double flame, helping it to stay lit even in erratic winds. The external flame burns slowly and at a lower temperature than the internal flame. This flame is big and bright orange, so it can be seen clearly; but it is unstable in winds. The interior flame burns hotter, producing a blue flame that is small but very stable, because its internal location protects it from the wind. It acts like a pilot light, able to relight the external flame should it go out.

Photo courtesy www.areamediafiamma.it/
Copyright © 2005 Torino 2006 ®

Professional pyrotechnician and effect specialist for hire, Florida Special Effects Companies - movie special effects - hollywood effects - stage pyrotechnics - theater effects - fire- flame - Pyrotechnic Fireworks Displays - Atmosphere Special effects - service show special effects - Florida Pyrotechnics Companies - snow - propane flames - C02 Blast Jets- confetti - Exploding Balloon Walls - Theatrical pyrotechnics - indoor fireworks - Aerotechnics - Smoke Rings - Flash pot - waterfalls - realistic falling snow - Cryogenic - sfx, fx, stadium effects - special effects department,Effect Specialists for your corporate, convention, commercial event, or private event in the USA

zigmont@effectspecialist.com

Warning
Do not attempt to recreate any FX effects seen on this site. We are professional and only experienced and legally approved over 21 can provide these services. Attempting to use propane with our the safety devices that are built in to our gear as well as firing pyrotechnics devices without training is dangerous. C02 can be very dangerous if your not a Certified effect specialist.

Effectspecialist.com provides pyrotechnics displays and propane flames presentations with full services nationwide We operate in North America United States we can service you in the follow cities with speedy services in;

Special effects for Entertainment Venues and clubs, snow machines Service in Alabama; Anniston, Birmingham, Dothan, Huntsville, Mobile, Montgomery, Tuscaloosa

High Range - High Volume Artificial or Fake Snow Flake Machines Service in Arizona; Flagstaff, Phoenix, Tucson, Yuma

Propane flames Service in Arkansas; Eureka Springs, Fayetteville, Fort Smith, Jonesboro, Little Rock, Monroe

Snow machines from flurries to a beautiful full blown Snowstorm Blizzard , cyro co2 and ground fog Service in California; Anaheim, Antelope Valley, Antioch, Bakersfield, Burbank, Chico, Eureka, Fresno, Hollywood, Huntington Beach, Inland Empire, Lake Tahoe, Livermore Valley, Long Beach, Los Angeles, Medford, Monterey, Napa Valley, Oakland, Orange County, Palm Springs, Pasadena, Sacramento, San Diego, San Francisco, San Jose, Santa Barbara, Santa Monica, Temecula, Ventura County, Yuma

Theatrical FX and indoor pyrotechnics displays Service in Colorado: Aurora, Boulder, Colorado Springs, Denver, Fort Collins, Grand Junction, Vail,
Special effects Service in Connecticut, Danbury, Hartford, New Haven, Stamford

Fake snow machines gas FX flames Service in DC; District of Columbia

Low-level Displays Super Bowl Style Pyro and cyro Service in Delaware; Dover, Georgetown, Wilmington

special effect fake snow machines, foam machines pyrotechnics, fireworks and Propane dragonfly flames Service in Florida; Boca Raton, Daytona, Florida Keys, Fort Lauderdale, Fort Myers, Fort Pierce, Gainesville, Jacksonville, Marco Island, Melbourne, Miami, Ocala, Orlando, Panama City, Pensacola, Sarasota, Tallahassee, Tampa Bay, West Palm Beach

Fireworks fX Pyrotechnical, fake snow machines Service in Georgia; Albany Athens, Atlanta, Augusta, Columbus, Golden Isles, Macon, Savannah

Special effects Co2 outdoor snowfall machines Service in Hawaii; Hawaii Island, Honolulu, Kauai Island Lanaie Island, Maui, Molokai Island

foam machine rental Service for Idaho; Boise-Pocatello, Coeur D Alene, Idaho Falls, Lewiston, Sandpoint, Twin Falls

Pyrotechnics and flames Service in Illinois; Bloomington, Champaign, Chicago, Davenport, Evanston, Mt. Vernon, Oak Lawn, Peoria, Quincy, Rockford, Springfield, Wheaton

FX fire and pyrotechnics table top gerbs Services Indiana; Evansville, Fort Wayne, Hammond, Indianapolis, Lafayette, South Bend, Terre Haute

Evaporating DRY Snow machines, pyrotechnics and flames Service in Iowa ; Cedar Rapids, Davenport, Des Moines, Ottumwa, Quincy, Rochester, Sioux City

Fireworks pyrotechnics, propane flame, snow machines Service in Kansas ; Dodge City, Goodland, Great Bend, Kansas City Lawrence, Manhattan, Salina, Topeka, Wichita

Full event services, snow machine FX Kentucky; Ashland, Bowling Green, Elizabethtown, Hopkinsville, Lexington, Louisville, Owensboro, Paducah

Bubbles FX, pyro Service in Louisiana ; Alexandria, Baton Rouge, Lafayette, Lake Charles, Monroe, New Orleans, Shreveport

inside Pyrotechnics or outdoors pyrotechnics displays Service in Maine; Augusta, Bangor, Lewiston, Ogunquit, Portland, Presque Isle, York

Cyro and snow falling displays Maryland; Annapolis, Baltimore, Columbia, Eastern Shore, Laurel, Montgomery County, Rockville, Salisbury, Southern,Western

Magic FX Service in Massachusetts with low ground fog; Birkshire County, Boston, Cape Cod, Lowell, Springfield, Worcester, Service for Michigan , Ann Arbor, Detroit, Flint, Gaylord, Grand Rapids, Jackson, Kalamazoo, Lansing, Marquette, Port Huron, Saginaw, Saint Clair Shores, Sault Saint Marie, Traverse City, Tri-Cities, Warren,

party foam machines and cyro jets Service in Minnesota; Duluth, Mankato, Minneapolis, Moorhead, Rochester, St. Cloud, St. Paul, Twin Cities

Fireworks and pyrotechnics, flame FX, snow machine rentals Service in Mississippi; Biloxi, Greenwood, Hattiesburg, Jackson, Meridian,Service in Missouri . Clinton, Columbia, Jefferson City, Joplin

Flames and propane fire Kansas City; Ottumwa, Paducah, Quincy, Sedalia, Springfield, St. Joseph, St. Louis,

Next FX protechnics products used in Servicing in Montana; , Billings, Bozeman, Butte, Glendive, Great Falls, Helena, Missoula

Fake snow maachines, Snow falling events, cyro jets, crawling smoke, consulting Service in California; Anaheim, Antelope Valley, Antioch, Bakersfield, Burbank, Chico, Eureka, Fresno, Hollywood, Huntington Beach, Inland Empire, Lake Tahoe, Livermore Valley Long Beach, Los Angeles, Medford, Monterey, Napa Valley, Oakland, Orange County, Palm Springs, Pasadena, Sacramento, San Diego, San Francisco, San Jose, Santa Barbara, Santa Monica, Temecula, Ventura County, Yuma

Special effects foam machines , pyro services Nebraska ; Beatrice, Cheyenne, Freemont, Grand Island, Lexington, Lincoln, Norfolk, North Platte, Ogallala, Omaha, ScottsBluff

special effectpropane Flame effects and indoor pyrotechnics , snow falling Service in Nevada; Lake Tahoe Las Vegas, Reno

Bubbles machines and foam machines Service in New Hampshire; Concord Dartmouth, Lakes Region, Manchester, Monadnock Region, North Woods, Seacoast Region, Southern, White Mountains

Full service special effects for movies and theme parks Service in New Jersey; Atlantic City, Bayonne, Belmar, Bloomfield, Camden, Carteret, Hackensack, Hoboken, Jersey City, Montclair, New Brunswick, Newark, Old Bridge, Paramus, Point Pleasant Seaside Heights, Secaucus, Trenton, Wildwood

Confetti and streamer and Snow Service in New Mexico Albuquerque, Santa Fe

Confetti and streamers special effect, artificial snow Service in New York; Albany, Binghamton, Brooklyn, Buffalo, Burlington, Elmira, Hudson Valley, Long Island-Nassau County, Long Island-Suffolk County, Long Island-The Hamptons, Manhattan New York City, NY City, Oneonta, Queens, Rochester, Rockland, Staten Island, Syracuse, Utica, Watertown, Westchester,

Pyrotechnical and fireworks, snow machines Service in North Carolina; Charlotte Durham, Fayetteville, Greensboro Greenville, Raleigh, Rockymount, Western, Wilmington, Winston Salem

special effects Service in North Dakota; Bismarck Dickinson, Fargo, Grand Forks, Jamestown, Minot, Williston

Pyrotechnicians and flame operator Services in Ohio; Akron Cincinnati, Cleveland Columbus Dayton Lima, Toledo, Wheeling, Youngstown, Zanesville

Special effect events, Gale Force Wind FansService in Oklahoma; Oklahoma City, Tulsa, Wichita Falls

FX machines, snow machine rental Services in Oregon; Bend, Eugene, Klamath Falls, Medford, Portland, Salem,Service in

Magic FX pyrotechnics, flame FX Special effect rentals Pennsylvania , Allentown, Erie, Harrisburg, Johnstown, Philadelphia, Pittsburgh, Poconos, State College, Wilkes Barre, York

Cryogenic Venturi Smoke Effects FX services in Rhode Island; Newport, Providence

snow displays Services in South Carolina ;artificial indoor snow Charleston, Columbia, Florence, Greenville, Hilton Head, Myrtle Beach, Rock Hill

Aerotechnics Confetti & Streamers, Foam machine Service in South Dakota; Rapid City, Sioux City, Sioux Falls

snowmastesr snow machines, propane flames, Licensed flames pyrotechnics operatorService in Tennessee; Chattanooga, Jackson, Knoxville, Memphis, Nashville, Tri Cities

Pyrotechnics and Gas Flames operators, Motorized Spinning gerbs snow machines, Licensed flames pyrotechnics operato services for Texas ; Abilene, Amarillo, Austin, Bay City, Beaumont, Corpus Christi, Dallas, El Paso, Fort Worth, Galveston, Harlingen, Houston, Laredo, Lubbock, Odessa, San Angelo, San Antonio, Texarkana, Tyler, Victoria, Waco, Wichita Falls

FX consulting Service in Utah; Provo, Salt Lake City

indoor snowfall machines Service in Vermont; Burlington, Manchester, Middlebury

Pyro and flame Services in Virginia; Charlottesville, Fairfax, Fredericksburg, Hampton, Harrisonburg, Manassas, Norfolk, Northern, Richmond, Roanoke, Vienna

special effect machines and pyrotechnics and fireworks Service in Washington; Olympia, Seattle, Spokane, Tacoma, Vancouver, Wenatchee, Yakima

Confetti and bubble machines Service in West Virginia; Beckley, Charleston, Clarksburg, Huntington, Parkersburg, Wheeling

Smoke FX for corporate events Service in Wisconsin; Appleton, Ashland, Eau Claire, Green Bay, Janesville, Madison, Milwaukee, Oshkosh, Prairie du Chien, Racine, Rhinelander, Superior, Waukesha, Wausau

Theatrical effects and pyrotechnic Service in Wyoming; Casper, Cheyenne, Gillette, Jackson Hole, Rock Springs